Engineering systems and site supply

BOSStructural fire protection

Fire protection for ductwork and building structures

Russian manufacturer of non-combustible basalt-fibre materials: ventilation and smoke extraction, supports and fixings, load-bearing structures.

SYSTEM	COMPOSITION	THICKNESS	RATING
PRO-МБОР-VENT	PRO-МБОР roll material with Kleber fire-retardant compound	5–26 mm	EI 30 — EI 240
PRO-VENT	Stitched mat of ultra-fine basalt fibre without binder	20–60 mm	EI 60 — EI 180
PRO-COMPLEX-VENT	Fire protection of fixings: threaded rods, cross-beams, hanger assemblies (PRO-PIN-VENT)	13 mm	per system
PRO-METAL	Fire protection of steel structures: roll material with Kleber compound	5 / 10 / 16 mm	R 45 — R 150
PRO-BETON	Structural fire protection of reinforced concrete	per design	up to REI 240
PRO-CONDITION	Fire protection of air-conditioning pipework	per design	up to REI 150

Products and illustration: BOS · bos-pro.ru

BOSTechnical thermal insulation

Thermal insulation for pipelines, equipment and tanks

Basalt pipe sections, mats, cords and cladding materials, plus elastomeric foam tubes — in the same order as fire protection.

BOS PIPE

Slit pipe sections and half-shells for heating and water supply pipelines.

BOS-VENT

Stitched basalt-fibre mat without binder, up to +900 °C.

BOS-THERM

Cut insulation pieces for pipelines and fittings.

BOS-CORD

Basalt cord (ShBT) for sealing joints and gaps.

BOS-PROTECTION

Cladding layer protecting insulation from external impact.

Fixings and compounds

Kleber mastic, PRO-FIX sealant, tape, mesh, wire, ties, banding.

BOS-FLEX-K · elastomeric foam

TU 22.19.20-007-98401890-2025

Tubes for water supply and drainage, air conditioning, heating and district heating: prevent condensation and reduce heat loss.

COMBUSTIBILITYG1

DENSITY40–60 kg/m³

INNER DIAMETER6–114 mm

THICKNESS6–32 mm

TEMPERATURE−50…+110 °C

NG/G1 certificates and BIM models on request · bos-pro.ru

USYSTEMSPiping systems

Pipes, fittings and building systems

Heating, cooling and water supply — from pipe to installation tools.

Piping systems

PE-Xa Radi Pipe and Water Pipe, Stabil Pipe and MLC. Pre-insulated pipes, protective sleeves and fixings.

Fittings and connections

SBM, axial, press and compression fittings, elbows, tees, wall plates.

Heating and cooling

Underfloor, wall and industrial systems, Minitec, surface heating panels.

Manifolds and controls

Manifolds, cabinets, pump and mixing units, 230/24 V wired and wireless controls.

External networks

Pre-insulated pipes: Thermo, Varia, Aqua, Quattro, Supra, Supra Plus.

Tools and installation

Pipe cutters, calibrators, expansion, axial and press tools.

Products and photos: USYSTEMS · usystems.ru

USYSTEMSSnow melting

Installing snow-melting circuits. Photo: USYSTEMS.

Snow melting and outdoor surface heating

Hydronic surface heating against snow and ice.

Outdoor areas

Residential courtyards, pavements, roads, ramps, car parks, entrances and football pitches.

System components

PE-Xa circuits under the surface, MAGNA or PE-RT manifolds, fittings and accessories.

Automatic control

Heating driven by precipitation and temperature sensors, remote monitoring and dispatching.

Project-specific design

Thermal and hydraulic calculation, heat supply scheme, manifold layout.

Products and photos: USYSTEMS · usystems.ru

AYVAZExpansion joints and valves

Expansion joints, flexible hoses and valves

A Turkish manufacturer with over 70 years of history: its own factories and deliveries to more than 100 countries. Products are certified to ASME, CE, EAC and other standards.

Expansion joints

Standard and custom metal bellows, rubber and fabric expansion joints — for absorbing thermal expansion and vibration.

Flexible metal hoses

For gas, water and HVAC systems, industrial hoses and sprinkler connection hoses.

Valves

Isolation, control, safety relief and balancing valves.

Steam and condensate

Steam traps, blowdown systems, heat exchangers and steam line equipment.

Level control

Level indicators, on-off and proportional controllers, flow meters.

Fire fighting

Equipment for fire fighting systems.

Products and photos: Ayvaz · ayvaz.com

ODISSBuilding systems automation

Automation and control units

Control panels, dispatching and piping units for ventilation, heating and air-conditioning systems.

Control panels

Automation of ventilation systems. Panel configuration selected for the equipment and control logic.

Dispatching

Solutions for monitoring and controlling building systems to your technical brief.

Mixing units

Control units for air handling units, air curtains and fan coils. Selected by flow rate, pressure drop and temperature schedule.

Products and photos: ODISS · odiss.ru

Additional supply

Materials and equipment to your specification

Items usually sourced from separate suppliers are included in the project's single order: selected to the specification, with alternatives agreed in advance.

Pumping equipment

Circulation, booster and drainage solutions. Selected by application, flow rate and head.

Shut-off and control valves

Ball valves, control valves, gate valves and related pipework components.

Ventilation systems

Ductwork, dampers, grilles, supports and installation components.

Installation accessories

Connectors, adapters, seals and accessories.

Construction site supply

Consumables, fasteners and equipment

For general construction and installation work, operation and day-to-day site needs — regular deliveries on request from the site manager or procurement team.

Cutting and grinding consumables

Diamond and cutting discs, saw blades, drill bits, SDS bits, abrasives.

Anchors and fasteners

Chemical and mechanical anchors, wall plugs, screws, bolts, nuts, threaded rods.

General building materials

Dry mixes, sheet materials, formwork accessories, membranes and mesh.

Tools and construction chemicals

Hand tools, welding consumables, sealants, foams, adhesives, paints.

PPE and safety

Workwear, footwear, helmets, gloves, eye, respiratory and fall protection.

Site equipment

Cables, extension leads, lighting, cleaning supplies, packaging.